Journal of Energy Chemistry
ISSN 1003-9953
          Home | | | |
     
Journal of Energy Chemistry 2013, Vol. 22 Issue (1) :39-47    DOI:
Current Issue | Next Issue | Archive | Adv Search << Previous Articles | Next Articles >>

Hydrate capture CO2 from shifted synthesis gas, flue gas and sour natural gas or biogas

Yanhong Wang, Xuemei Lang, Shuanshi Fan*

School of Chemistry and Chemical Engineering, Key Lab of Enhanced Heat Transfer and Energy Conservation, Ministry of Education, South China

University of Technology, Guangzhou 510640, Guangdong, China


Abstract

 CO2 capture by hydrate formation is a novel gas separation technology, by which CO2 is selectively engaged in the cages of hydrate and is separated with other gases, based on the differences of phase equilibrium for CO2 and other gases. However, rigorous temperature and pressure, high energy cost and industrialized hydration separator dragged the development of the hydrate based CO2 capture. In this paper, the key problems in CO2 capture from the different sources such as shifted synthesis gas, flue gas and sour natural gas or biogas were analyzed. For shifted synthesis gas and flue gas, its high energy consumption is the barrier, and for the sour natural gas or biogas (CO2/CH4 system), the bottleneck is how to enhance the selectivity of CO2 hydration. For these gases, scale-up is the main difficulty. Also, this paper explored the possibility of separating different gases by selective hydrate formation and reviewed the progress of CO2 separation from shifted synthesis gas, flue gas and sour natural gas or biogas.
Keywords: clathrate hydrate CO2 capture hydrogen shifted synthesis gas flue gas sour natural gas or biogas   
Received: 2012-12-24; published: 2013-02-06
Cite this article:   
Yanhong Wang, Xuemei Lang, Shuanshi Fan* .Hydrate capture CO2 from shifted synthesis gas, flue gas and sour natural gas or biogas[J]  Journal of Energy Chemistry, 2013,V22(1): 39-47
URL:  
http://www.jenergchem.org/EN/     或     http://www.jenergchem.org/EN/Y2013/V22/I1/39
[1] Houghton J T, Ding Y, Griggs D J, Noguer M, van der Linden P J, Dai X, Maskell K, Johnson C A. Climate Change 2001: The Scientific Basis, New York: Cambridge University Press, 2001
[2] Stewart C, Hessami M. Energy Conv Manag, 2005, 46: 403
[3] Phan A, Doonan C J, Uribe-Romo F J, Knobler C B, O'Keeffe M, Yaghi O M. Acc Chem Res, 2010, 43: 58
[4] Krishna R, van Baten J M. J Membr Sci, 2010, 360: 323
[5] Banerjee R, Phan A, Wang B, Knobler C, Furukawa H, O'Keeffe M, Yaghi O M. Science, 2008, 319: 939
[6] Kumar R, Linga P, Ripmeester J A, Englezos P. J Environ Eng-ASCE, 2009, 135: 411
[7] Shimada W, Ebinuma T, Oyama H, Kamata Y, Takeya S, Uchida T, Nagao J, Narita H. Japan J Appl Phys Part2-Lett, 2003, 42: L129
[8] Kiyono F. Abstracts Pap Am Chem Soc, 2000, 220: U392
[9] Kang S P, Lee H. Environ Sci Technol, 2000, 34: 4397
[10] Yang H Q, Xu Z H, Fan M H, Gupta R, Slimane R B, Bland A E, Wright I. J Environ Sci, 2008, 20: 14
[11] Sloan E D. Clathrate Hydrates of Natural Gases, New York: Marcel Dekker, 1997
[12] Dyadin Y A, Larionov É G, Aladko E Y, Manakov A Y, Zhurko F V, Mikina T V, Komarov V Y, Grachev E V. J Struct Chem, 1999, 40(5): 790
[13] Dyadin Y A, Larionov É G, Manakov A Y, Zhurko F V, Aladko E Y, Mikina T V, Komarov V Y. Mendeleev Commun, 1999, 9(5): 209
[14] Chapoy A, Gholinezhad J, Tohidi B. J Chem Eng Data, 2010, 55: 5323
[15] Van Cleeff A, Diepen G A M. Recl Trav Chim Pays-Bas, 1960, 79: 582
[16] Deaton W M, Frost E M J. ``Gas Hydrates and Their Relation to the Operation of Natural-Gas Pipe Lines", Bureau of Mines, Amarillo, TX (USA). Helium Research Center, 1946
[17] Fan S S, Guo T M. J Chem Eng Data, 1999, 44: 829
[18] Li X S, Xia Z M, Chen Z Y, Yan K F, Li G, Wu H J. J Chem Eng Data, 2010, 55: 2180
[19] Dalmazzone D, Clausse D, Dalmazzone C, Herzhaft B. Am Mineral, 2004, 8(9): 1183
[20] van Denderen M, Ineke E, Golombok M. Ind Eng Chem Res, 2009, 48: 5802
[21] Kang S P, Lee H, Ryu B J. J Chem Thermodyn, 2001, 33: 513
[22] Lang X M, Fan S S, Wang Y H. J Nat Gas Chem, 2010, 19: 203
[23] Long F, Fan S S, Wang Y H, Lang X M. J Nat Gas Chem, 2010, 19: 251
[24] Wang Y H, Lang X M, Fan S S. J Nat Gas Chem, 2012, 21: 299
[25] Fan S S, Li S F, Wang J Q, Lang X M, Wang Y H. Energ Fuels, 2009, 23: 4202
[26] Li S F. [PhD Dissertation]. Guangzhou: South China University of Technology, 2010
[27] Seo Y T, Kang S P, Lee H, Lee C S, Sung W M. Korean J Chem Eng, 2000, 17: 659
[28] Seo Y T, Kang S P, Lee S Y, Lee H. J Chem Eng Data, 2008, 53: 2833
[29] Li S F, Fan S S, Wang J Q, Lang X M, Wang Y H. J Chem Eng Data, 2010, 55: 3212
[30] Zhong D L, Ye Y, Yang C. J Chem Eng Data, 2011, 56: 2899
[31] Mohammadi A H, Eslamimanesh A, Belandria V, Richon D, Naidoo P, Ramjugernath D. J Chem Thermodyn, 2012, 46: 57
[32] Makino T, Yamamoto T, Nagata K, Sakamoto H, Hashimoto S, Sugahara T, Ohgaki K. J Chem Eng Data, 2010, 55: 839
[33] Majumdar A, Maini B, Bishnoi P R, Clarke M A. J Chem Eng Data, 2012, 57: 2322
[34] Mayoufi N, Dalmazzone D, Furst W, Delahaye A, Fournaison L. J Chem Eng Data, 2010, 55: 1271
[35] Mayoufi N, Dalmazzone D, Delahaye A, Clain P, Fournaison L, Furst W. J Chem Eng Data, 2011, 56: 2987
[36] IPCC. Carbon Dioxide Capture and Storage: Special Report of the Intergovernmental Panel on Climate Change. Cambridge: Cambridge University Press, 2005
[37] Kumar R, Wu H J, Englezos P. Fluid Phase Equilibr, 2006, 244: 167
[38] Hashimoto S, Murayama S, Sugahara T, Ohgaki K. J Chem Eng Data, 2006, 51: 1884
[39] Lee H J, Lee J D, Linga P, Englezos P, Kim Y S, Lee M S, Kim Y D. Energy, 2010, 35: 2729
[40] Zhang J S, Lee J W. J Chem Eng Data, 2009, 54: 659
[41] Li X S, Xia Z M, Chen Z Y, Yan K F, Li G, Wu H J. Ind Eng Chem Res, 2010, 49: 11614
[42] Li X S, Xu C G, Chen Z Y, Wu H J. Energy, 2011, 36: 1394
[43] Linga P. Kumar R. Englezos P. J Hazard Mater, 2007, 149: 625
[44] Li X S, Xia Z M, Chen Z Y, Wu H J. Energy Fuel, 2011, 25: 1302
[45] Surovtseva D, Amin R, Barifcani A. Chem Eng Res Des, 2011, 89: 1752
[46] Xu C G, Li X S, Lv Q N, Chen Z Y, Cai J. Energy, 2012, 44: 358
[47] Lv Q N, Li X S, Xu C G, Chen Z Y. Ind Eng Chem Res, 2012, 51: 5967
[48] Kang S P, Lee H, Lee C S, Sung W M. Fluid Phase Equilib, 2001, 185: 101
[49] Linga P, Adeyemo A, Englezos P. Environ Sci Technol, 2008, 42: 315
[50] Li X S, Xu C G, Chen Z Y, Wu H J. Energy2010, 35: 3902
[51] Li S F, Fan S S, Wang J Q, Lang X M, Liang D Q. J Nat Gas Chem, 2009, 18: 15
[52] Kao C Y, Chiu S Y, Huang T T, Dai L, Wang G H, Tseng C P, Chen C H, Lin C S. Biomass Bioenerg, 2012, 36: 132
[53] Gaudette J. [MS Dissertation]. McGill University, 2007
[54] Servio P, Lagers F, Peters C, Englezos P. Fluid Phase Equilib, 1999, 158: 795
[55] Xia Z M, Chen Z Y, Li X S, Zhang Y, Yan K F, Lv Q N, Xu C G, Cai J. J Chem Eng Data, 2012, 57: 3290
[56] Nie J H. [MS Dissertation]. Guangzhou: South China University of Technology, 2012
[57] Dabrowski N, Windmeier C, Oellrich L R. Energy Fuels, 2009, 23: 5603
[58] Malegaonkar M B, Dholabhai P D, Bishno P R. Can J Chem Eng, 1997, 75: 1090
[59] Golombok M, Ineke E, Luzardo J C R, He Y Y, Zitha P. Environ Chem Lett, 2009, 7: 325
[60] Beeskow-Strauch B, Schicks J M. Energies, 2012, 5: 420
[61] Horvat K, Kerkar P, Jones K, Mahajan D. Energies, 2012, 5: 2248
[1] Yousef Salamata, Abdolreza Moghadassi, Mohammad Illbeigi, Ali Eslamimanesh, Amir H. Mohammadi* . Experimental study of hydrogen sulfide hydrate formation: Induction time in the presence and absence of kinetic inhibitor[J]. Journal of Energy Chemistry, 2013,22(1): 114-118
[2] Shengguo Hui, Bo Zhang, Suhua Zhang, Wei Li*.In situ IR study of dimethyl oxalate hydrogenation to ethylene glycol over Cu/SiO2 catalyst [J]. Journal of Energy Chemistry, 2012,21(6): 753-758
[3] Jianbo Zhang, Lijun Jin, Shengwei Zhu, Haoquan Hu*.Preparation of mesoporous activated carbons from coal liquefaction residue for methane decomposition [J]. Journal of Energy Chemistry, 2012,21(6): 759-766
[4] Dongyan Xu*, Lin Zhao, Ping Dai, Shengfu Ji.Hydrogen generation from methanolysis of sodium borohydride over Co/Al2O3 catalyst [J]. Journal of Energy Chemistry, 2012,21(5): 488-494
[5] Antonio C. D. Freitas, Reginaldo Guirardello*.Oxidative reforming of methane for hydrogen and synthesis gas production: Thermodynamic equilibrium analysis [J]. Journal of Energy Chemistry, 2012,21(5): 571-580
[6] Foad Mehri, Majid Taghizadeh*.Performance assessment of a spiral methanol to hydrogen fuel processor for fuel cell applications [J]. Journal of Energy Chemistry, 2012,21(5): 526-533
[7] S. Arndt, B. Uysal, A. Berthold, T. Otrebma, Y. Aksu, M. Driess, R. Schom?cker* .Supported ZnO catalysts for the conversion of alkanes: About the metamorphosis of a heterogeneous catalyst [J]. Journal of Energy Chemistry, 2012,21(5): 581-594
[8] Abhishek Joshi, Prathyusha Mekala, Jitendra S. Sangwai* .Modeling phase equilibria of semiclathrate hydrates of CH4, CO2 and N2 in aqueous solution of tetra-n-butyl ammonium bromide [J]. Journal of Energy Chemistry, 2012,21(4): 459-465
[9] Qingming Gu, Dan Han, Lei Shi, Qi Sun*.Styrene epoxidation with hydrogen peroxide over calcium oxide catalysts prepared from various precursors [J]. Journal of Energy Chemistry, 2012,21(4): 452-458
[10] Jun Xiong, Xinfa Dong*, Lingling Li .CO selective methanation in hydrogen-rich gas mixtures over carbon nanotube supported Ru-based catalysts [J]. Journal of Energy Chemistry, 2012,21(4): 445-451
[11] D. Torres, S. de Llobet, J. L. Pinilla, M. J. Lázaro, I. Suelves*, R. Moliner.Hydrogen production by catalytic decomposition of methane using a Fe-based catalyst in a fluidized bed reactor[J]. Journal of Energy Chemistry, 2012,21(4): 367-373
[12] Mengwei Xue, Yuming Zhou*, Yiwei Zhang, Xuan Liu, Yongzheng Duan, Xiaoli Sheng .Effect of cerium addition on catalytic performance of PtSnNa/ZSM-5 catalyst for propane dehydrogenation [J]. Journal of Energy Chemistry, 2012,21(3): 324-331
[13] Ke Wang, Hongyan Shang, Lin Li, Xinlong Yan, Zifeng Yan, Chenguang Liu, Qingfang Zha* .Efficient CO2 capture on low-cost silica gel modified by polyethyleneimine[J]. Journal of Energy Chemistry, 2012,21(3): 319-323
[14] Yonghua Zhou, Jing Liu, Xingyun Li, Xiulian Pan*, Xinhe Bao*.Selectivity modulation in the consecutive hydrogenation of benzaldehyde via functionalization of carbon nanotubes  (Special Column)[J]. Journal of Energy Chemistry, 2012,21(3): 241-245
[15] Yongzheng Duan, Yuming Zhou*, Yiwei Zhang, Xiaoli Sheng, Shijian Zhou, Zewu Zhang.Effect of aluminum modification on catalytic properties of PtSn-based catalysts supported on SBA-15 for propane dehydrogenation[J]. Journal of Energy Chemistry, 2012,21(2): 207-214
Copyright 2010 by Journal of Energy Chemistry